Top rated home sofa textile fabric manufacturer and supplier: The pile-up of flannel is formed by the repeated action of the steel wire needle tip of the pile-up machine to pull up some fibers on the surface of the grey cloth, and the pile is required to be short, dense and uniform. Printed flannel is brushed before printing, while bleached and variegated flannel is brushed at the end. The warp used in the grey cloth of flannel should be fine; Weft yarns should be thick and have less twist. The cotton fiber for spinning weft should be thick and have good uniformity. The warp density of the fabric is smaller, and the weft density is larger, so that the weft emerges on the surface, which is beneficial to the formation of full and uniform fluff of weft cotton fibers. After napping, the weft strength of flannel is greatly lost, so it is very important to master the quality of cotton yarn and the operation of napping process. A cotton cloth with fluff, raised on one or both sides, especially for underwear and pajamas. Discover many more info at sofa fabric factory.

Printed cloth can be divided into transfer printing, infiltration printing and reactive printing according to different processes. Home and sofa are basically made of reactive printed craft cloth. Advantages: Colorful and bright. No pilling, no burr and no deformation. Cleaning method: It is best to wash it with cold water or warm water first, and it is not advisable to soak and wash it with boiling water, nor to pile it up for too long.

So far, the best furniture is the back cover with grid cloth, which does not need to be used as nail gun slot, and very few furniture will choose this. Among the export handicrafts, Japan requires that there should be a nail gun slot to hit the nail gun at the back cover, and the nail gun that can be hit cannot be scratched, because as long as the nail gun slot is opened, the nail gun will be a straight line, so it is easy to distinguish. Japan’s export requirements: the nail gun is horizontal and vertical without waste nails, and the back cover fabric is wrinkle-free. The contrast between the high-standard nail gun technology and the inferior nail gun technology is obvious. The inferior nail gun is crooked, the back cover fabric is uneven, and there are waste nails, as shown in the following picture.

Compared with sponge, eiderdown is more expensive and fluffy, and the sitting feeling is much better than sponge, and the sofa is not easy to deform, but eiderdown has several shortcomings: slow rebound, high cost, difficult to take care of, unsuitable for asthma people, and fever in summer. It is recommended to adapt to the use of cushions. Latex is the highest cost among the three materials at present. Latex has the advantages of good air permeability, environmental protection and easy care. Latex protein in latex is a good anti-mite raw material, which is warm in winter and cool in summer without odor and allergy. The disadvantage is low yield.

According to composition, best sofa fabric Can be divided into polyester, cotton, linen and so on. We mainly produce 100% polyester artificial leather, such as bronzed suede , technology fabric and so on. These wholesale sofa fabrics are of good quality and favorable price. It has two shuttles, bottom yarn is FDY, face yarn is sea-island filament. The normal weight of 75D suede is 120gsm, the normal weight of 50D suede is 110gsm. Read extra information on https://www.yiertextile.com/.

Flocking cloth is characterized by its rich and bright colors, good three-dimensional sense and soft touch, which is flat and friction-resistant. There are several points for attention in cleaning flocking cloth: do not soak it directly in water for cleaning and rubbing; If the flannel is wet, don’t twist it hard to prevent the fluff from falling off because of excessive force; For a small amount of stains, cotton gauze can be dipped in appropriate amount of gasoline or alcohol, and then gently wiped; If you wash it with water as a whole, you should brush the fluff flat in one direction, then press the water off by hand and dry it in a natural state.

Our company believes in the belief that “Your needs are the direction of our work; Your satisfaction is the driving force for our progress”. These various products are sold well to clients in such countries and regions as Europe, South America, North America, Latin America, Southeast Asia, the Middle East and some African countries. The quality of the products are well received by our clients. Dedicated to strict quality control and thoughtful customer service, our experienced staff members are always available to discuss your requirements and ensure full customer satisfaction.